Toyota, Honda & Subaru Starter Failure | MDH MOTORS

13 Июн 2015 | Author: | No comments yet »
Toyota Fine N

Toyota, Honda #038; Starter Failure

Starter Clicks, Engine Does Not

A common problem with Imports “The starter clicks”. It is also common for to happen intermittently. Most . Toyota and Subaru’s use a gear starter for their vehicles. starters are practically bulletproof, but does not mean they ever fail. The question is, is causing this? Well, 90% of the the starter motor is fine and it is not getting the correct amount of to crank over the engine. does not mean you have a problem, in which if that the situation it would cause the symptoms. This is because situations are caused by the same problem, not enough current to the motor.

Does this mean the starter needs replaced?


The is NO; you can fix your starter with a few parts that cost than $10.00. Now, if you don’t have any way of testing the system to know if you battery is this or if it’s the starter. I give you a couple of quick that you can do to differentiate the two. charge your battery or try the vehicle. If this eliminates the then you’re on your way to the but be careful. A lot of times people get this way because when charge or jump the battery it causes the starter to work though there is still a and you could be stranded later the road. The best thing to do is the ignition key, over and from the off position to the cranking Do this to where you can hear the clicking each time you the key. If after multiple you get the vehicle to crank over you found the issue.

What causes my starter to click?

Contact points are burned up on a gear reduction This usually all that wrong with these Another view of burned up points on a gear reduction

The answer is the starter contact These points get burned up not current to the actual starter The way a starter works is the actual is permanently grounded and while you the engine there is a magnetic plunger that slides in to contact with the power to the grounded motor side. powers your starter to crank over the engine. you release the key the plunger is spring to return the plunger and stop the motor from turning. contact points get burned up time and prevent the correct of current to your starter My experience tells me that repair shops out there like to just sell you a new starter when it doesn’t need replaced. If you have had a starter replaced on your take a look at the repair and see how much you paid for that Wouldn’t you rather fix it with a part? Like a said of the time this is all that is

How To Replace The Starter Contact

New contact points and the contact The plunger is the part that is activated, you can see the return spring behind it. Typical gear starter. This particular is out of a Toyota Tacoma.

This is simple procedure. You will need basic tools to and install the starter and then a for cleaning the plunger side of the Take a look at the picture to get an idea of what you’re with then follow steps.

Remove the starter.

the back cover and pull out the this will need to be cleaned to allow good current to pass between (you should be able to see it makes contact).

Replace contact points one side at a this way you don’t get them up (they are different for each

Toyota Fine N

Install the cleaned up plunger and it with di-electric grease.

battery, clean battery (just for good measure).

the starter and re-test.

Where do I get contact points?

You can sometimes get points at a regular parts store such as Napa. but a lot of the they won’t even what your talking I usually either get them an automotive electrical supply such as ABE Electric or the dealership.

Now I’m not why, but I have never able to find the plunger and never been successful at the washer to replace it or flip it. If you find a place that can get let me know.

Starter Problems? Get a Free AVR System Diagnosis At MDH Motors

an appointement today or anytime. feel free to call me for (503) 704-4687. In an emergency contact Big Pauls Towing for towing.

Toyota Fine N
Toyota Fine N
Toyota Fine N

Interesting Articles



Смотрите также:
Tagged as:

Here you can write a commentary on the recording "Toyota, Honda & Subaru Starter Failure | MDH MOTORS".

Sign in, to write a review.

Twitter-news
Our partners
Follow us
Contact us
Our contacts

dima911@gmail.com

Born in the USSR

423360519

About this site

For all questions about advertising, please contact listed on the site.


Toyota cars catalog with specifications, pictures, ratings, reviews and discusssions about cars Toyota.